Studies on Physiochemical Properties of Tomato Powder as Affected by Different Dehydration Methods and Pretreatments

Authors: Reihaneh Ahmadzadeh Ghavidel, Mehdi Ghiafeh Davoodi

Abstract:

Tomato powder has good potential as substitute of tomato paste and other tomato products. In order to protect physicochemical properties and nutritional quality of tomato during dehydration process, investigation was carried out using different drying methods and pretreatments. Solar drier and continuous conveyor (tunnel) drier were used for dehydration where as calcium chloride (CaCl2), potassium metabisulphite (KMS), calcium chloride and potassium metabisulphite (CaCl2 +KMS), and sodium chloride (NaCl) selected for treatment.. lycopene content, dehydration ratio, rehydration ratio and non-enzymatic browning in addition to moisture, sugar and titrable acidity were studied. Results show that pre-treatment with CaCl2 and NaCl increased water removal and moisture mobility in tomato slices during drying of tomatoes. Where CaCl2 used along with KMS the NEB was recorded the least compared to other treatments and the best results were obtained while using the two chemicals in combination form. Storage studies in LDPE polymeric and metalized polyesters films showed less changes in the products packed in metallized polyester pouches and even after 6 months lycopene content did not decrease more than 20% as compared to the control sample and provide extension of shelf life in acceptable condition for 6 months. In most of the quality characteristics tunnel drier samples presented better values in comparison to solar drier.

Keywords: Dehydration, Tomato powder, Lycopene, Browning

Digital Object Identifier (DOI): doi.org/10.5281/zenodo.1077153

References:

[1] S. Rangana,. "Handbook of analysis and quality control for fruit and vegetable products". Tata McGraw-Hill Publishing Co. Ltd, ED-6, pp. 300-380, Jan. 2000.
[2] M. Dubois, K.A. Gilles, J.K. Hamilton, P.A. Rebers, and F. Smith, "A mehtode for carbohydrate stimation," Anal. Chem., vol. 28, pp. 350-353, 1956.
[3] D.J. Hart, and K.J. Scott, "Development and evaluation of an HPLC method for the analysis of carotenoids in Foods, and the measurement of the carotenoids content of vegetables and fruits commonly consumed in the UK," Food Chem., vol. 54, pp. 101-111, 1995.
[4] A. A. El- Sebii, S. Abdoul-Enein, M. R.I. Ramadan, & H.G. El-Gohary, "Experimental investigation of an indivect type natural convection solar dryer," Energy Conversion and Management, vol. 43, pp. 225-226, 2002.
[5] W. W. M. McMinn, and T. R. A. Magee, "Physical characteristics of dehydrated potatoes," J. Food Eng., vol. 33, pp. 49-55, 1997.
[6] D. G. Prabhanjan, H. S. Ramaswamay, and G. S. V. Raghavan, "Microware assisted air drying of thin layer carrots," J. Food Eng., vol. 25, pp. 283-293, 1995.
[7] K. Gierschner, W. John, and S. Philippos, "Specific modification of cell wall hydrocolloids in a new technique for processing high quality canned vegetables," Deutsche Lebensmitel-Rund Schan, vol. 91, pp.103- 109, 1995.
[8] O. A. Olorunda, O. C. Aworh, and C. N. Onuha, "Upgrading quality of dried tomato: Effect of drying methods, conditions and pre-drying treatments," J. Sci. Food Agric., vol. 52, pp. 447-454, 1990.
[9] R. G. Gupta, and N. Nath, "Drying of tomatoes," J. Food Sci. Tech., vol. 21, pp. 372 - 376, 1984.
[10] M. Y. Gallali, Y. S. Abujnab, and D. F. Bannari, "Preservation of fruits and vegetables using solar drier: a comparative study of natural and solar drying, III; chemical analysis and sensory evaluation data of the dried samples," Renewable Energy, vol. 19, pp. 203-212, 2000.
[11] S. O. Okanlawon, M. H. IbraHIM, and A. O. Oyebani, "Effect of pre drying treatment on the storage of dried tomato," Tropical Sci., vol. 42, pp. 40-41, 2002.
[12] S. K. Sharma, and M. L. Maguer, "Kinetics of Lycopene degradation in tomato pulp solid under different processing and storage condition," Food Res. Intl., vol. 29, pp. 309-315, 1996.
[13] A. K. Baloch, K. A. Buckle, and R. A. Edwards, "Effect of sulphur dioxide and blanching on stability of carotenoids of dehydrated carrot," J. Sci. Food Agric., vol.40, pp. 179-187, 1987.
[14] S. Poretta, and L. Sandei, "Effect of chemical composition on nonenzymic browning in tomato products," Industrie Alimentari, vol. 29, pp. 113-116, 1990.
[15] M. Simon, J. R. Wagner, V. G. Silveira, and C. E. Hendel, "Calcium chloride as Non-Enzymatic Browning Retardant for Dehydrated White potatoes," Food Tech., vol. 12, pp. 271-275, 1955.
[16] W. A. Baloch, S. Khan, and A. K. Baloch, "Influence of chemical additives on the stability of dried tomato powder," Intl. J. Food Sci. Tech., vol. 32, pp. 117-120, 1997.
[17] G. A. Picchioni, "Membrane lipid metabolism, cell permeability and ultra structural changes in lightly processed carrot," J. Food Sci., vol. 59, pp. 601-605, 1994.
[18] J. C. Rosen, and A. A. Kader, "Post harvest physiology and quality maintenance of sliced pear and strawberry fruits," J. Food Sci., vol. 54, pp. 656 - 659, 1989.
[19] H. Izumi, and A. E. Watada, "Calcium treatments affect storage quality of shredded carrot," J. Food Sci., vol. 59, pp. 106 - 109, 1994.
[20] G. M. Glenn, and B. W. Poovaiah, "Calcium- mediated post harvest changes in texture and cell wall structure and composition in Golden Delicious apples," J. Am. Soc. Hort. Sci., vol. 115, pp. 962 - 968, 1990.
[21] E. M. Ahmed, S. Mirza, and A. G. Arreola, "Ultra structural and textural changes in processed carrot tissue," J. Food Quality, vol. 57, pp. 56-60, 1991.
[22] M. K. Krokida, and D. Marinos-Kouris, "Rehydration kinetics of dehydrated products," J. Food Eng., vol. 57, pp. 1-7, 2003.
[23] M. R. Okos, G. Narishman, R. K. Singh, and A. C. Weitnauer, "Food dehydration In: Handbook of Food Engineering," Marcel Dekker, pp. 437-562, 1992.
[24] P. P. Lewicki, H. V. Le, and W. P. Lazuka, "Effect of pretreatment on convective drying of tomatoes," J. Food Eng., vol. 54, pp. 141-146, 2002.
[25] S. Suguna, M. Usha, V. V. Screenarayanan, R. Raghupathy, L. Gotthandapani, "Dehydration of mushroom by sundrying, thin layer drying, fluidized bed drying and solar cabinet drying," J. Food Sci. Tech., vol. 32, pp. 384-388, 1995.
[26] J. Shi, M. Maguer, Y. Kadkuda, and A. Liptay, "Lycopene degradation and isomeration in tomato dehydration," Food Res. Intl., vol. 32, pp. 15- 21, 1999.
[27] V. R. Sagar, D. S. Khurdiya, and K. A. Balakrishnan, "Quality of dehydrated ripe mango slices as affected by packaging material and mode of packaging," J. Food Sci. Tech., vol. 36, pp. 67-70, 1999.
[28] K. K. Adom, "Combined effect of drying time and slice thickness on the solar drying of okra," J. Sci. Food Agric., vol. 73, pp. 315-320, 1997.